Hyundai Elantra / Avante X20 - 90,000KM Service

Sent my X20 due for 90K km service recently and here is the things being done at KBPJ Service Centre.

Odometer: 90138 km
1. Replace Oil Pan Plug Washer
2. Replace Oil Filter
3. Replace Engine oil - Castrol SLX 0W30 (Fully Synthetic oil)
4. Replace Brake Fluid - Castrol Brake Fluid Dot 4
5. Suspension Noise check

Castrol Brake Fluid Dot 4

They have tighten 1 bolt for lower arm which found loose during the suspension check. Other than that.. no comments so far.

Absorber? still thinking and looking for it. Not decided yet...

Hyundai Elantra / Avante X20 - Its Time For Service

Well, its time for 90K km service. 10K km more before my warranty expires.

Hyundai Elantra / Avante X20 - Aircond Cabin Filter

Its been a while since I received the filter but am too lazy to put it in. The filter is suppose to be replaced at every 15K km and I'm doing it after 80K km hehehe.

For tutorial on how to replace the Aircond cabin filter for Elantra/Avante X20, you can go here.

Hyundai Elantra / Avante X20 - Squeaking Sound from Head Unit Cover

I'm getting annoyed by the squeaking sound from the head unit cover. I notice that the cover looks like it was not installed properly and I have to push it in.. the sounds gone for a while but then, it happens again.

I believe most of the X20 owner have the same problems and don't be surprise when you remove the head unit cover, only 4 out of 8 clips were there (Wonder why another 4 is missing..hmmm)

Top of the cover (only 2 clips installed - 1 & 4, the remaining 2 missing) the same goes at the bottom

Not to prolong the issue, I just bought another 4 clips and have it installed.. and so far, I'm satisfied with the result.

Hyundai Elantra / Avante X20 - Tyre Crisis.

Arghh.. my new tyre hit the rear fender when driving on bumpy road.. Check with the tyre shop and they told me that Federal tyre is slightly wider in shape even compared to my previous Neuton.

It is very frustrating as if I know it earlier, I might go for another size or brand but have to admit apart from rubbing with the fender, the the tyre is not that bad.

Finally I decide to go with smaller size, 205/45/17 Federal 595 EVO tyre.

Travel down south next week.. with all new rubber.

Odometer: 81700

Hyundai Elantra / Avante X20 - Tyre Change.

Neuton 215/45/R17 tyre had served me for more than a year now (>40k km) and the thread is still in fair condition. However, there is crack spotted on it recently and frankly I didn't expect it to be this bad.

So today I went to the tyre shop to check thoroughly and found that 3 out of 4 tyre is effected. Here how it looks.
After much of thinking and negotiating with the shop, I finally decided to replace all 4 tyre with new Federal 595 215/45/R17.

Here is how the thread looks like..

Well I guess I have to change my tyre at every 40K km based on the history so far.. hmphhh. ;(

Hyundai Elantra / Avante X20 - 80,000KM Service

My X20 due for 80K km service today and here is the things being done at KBPJ Service Centre.

Odometer: 80767 km
1. Replace Radiator Coolant
2. Replace Oil Pan Plug Washer2. Replace Oil Filter
3. Replace Engine oil - Castrol SLX 0W30 (Fully Synthetic oil)
4. Replace Timing Belt, Roller and Idler bearings
5. Replace Aircond and Fan belt
6. Replace ATF - Castrol TQM-SP (4L)
7. Suspension check
8. Brake check


They have also replaced the fog lights under warranty.

Hyundai Elantra / Avante X20 - Trailing Arm.

The long waited adjustable trailing arm has finally arrives...

Stock and adjustable trailing arm.

I have it install today and the installation is quite easy.. there is 3 bolts involved, 2 for trailing arm (a1 & a2) and 1 for the absorber (a3) to ease the trailing arm bolt removal (as shown on the photo)... plug and play.

Before

After

After complete with the installation, I went to the tyre shop immediately for alignment correction. It is really exciting to see how easy the mechanic can adjust both the toe and chamber to get the right reading.
Done this as well.

Brake Test

Absorber Test

Next thing on the list is to send my ride for 80K km service.

MyVi SE 1.3A - 10000km / 3rd Service.

It is not yet 10K km but already pass its overdue date (sixth month) for service.

10000km / 3rd Service
Odometer: 7030km
Service Date: 17.04.2010
Service Centre: Perodua Sales S/B, Jalan Lapangan Terbang Subang.

Sent it for 3rd service and things done today:
1. Replace Engine oil - Semi Syn. 5W30
2. Replace gasket
3. Replace Oil filter
4. Top-up windshield washer
5. Top-up battery water
6. General check/service

next service will be after 6 months/10k km with this oil.other than that, I've install the acoustic insulator to front bonnetand anti-theft to all doors and bonnet.

Earth Hour 2010.. Show Your Support